FREE e-Newsletter
Important News - Hot Topics
Get them Now!

Michigan State Police Evaluate Aftermarket Tires

Michigan troopers evaluate six aftermarket tire brands for police vehicles.

January 13, 2012  |  by Paul Clinton and Greg Basich

The Firestone Firehawk GT Pursuit was one of several aftermarket tires tested by the Michigan State Police.
The Firestone Firehawk GT Pursuit was one of several aftermarket tires tested by the Michigan State Police.

The Michigan State Police's Precision Driving Unit has released the results of an intensive battery of tests measuring the ability of aftermarket tires to meet the often-punishing demands of law enforcement driving.

Troopers in the unit tested six tire brands—Cooper, Firestone, Goodyear, Nitto, Nokian, and Pirelli—on various law enforcement vehicles to rate the durability of aftermarket tires for agencies. During two weeks of testing in June, tires were studied in three major areas—braking, endurance, and steady-state turning.

In addition to the four individual tests, troopers also measured tire wear after two 50-lap runs. Tires were run counter clockwise for 50 laps and clockwise for another 50 laps. The percentage of wear for each tire was then then measured.

Tires were first tested for "straight line" stopping on dry asphalt—a benchmark test for vehicles during the unit's annual September evaluation of new police models. Distance to a dead stop is measured for the vehicle (or tire, in this case) traveling at 60mph.

Next, straight-line braking tests are done on wet jennite, a calcium silicate hydrate used to seal asphalt. Stopping distance is measured from 35mph to a dead stop.

The tires are then tested on wet asphalt with the driver braking into a turn from a speed of 40mph.

The steady-state turning test is completed in two parts. Drivers accelerate while turning in a clockwise and counter clockwise circle for each test. The tires are tested with and without electronic stability control.

The Precision Driving Unit compared aftermarket tires to original equipment manufacturer tires outfitted on fleet vehicles when built on the assembly line for the purposes of testing.

The MSP tested the following tires: the Goodyear Eagle RS-A on the Dodge Charger, Ford Crown Vic (CVPI), Chevrolet Caprice, Chevrolet Impala, and Chevrolet Tahoe; the Firestone Firehawk GT Pursuit on the Charger, Ford CVPI, and Tahoe; the Cooper CS4 on the Ford CVPI, Impala, and Charger; the Nokian WR G2 on the Caprice and Impala; the Nitto NT 850 Plus on the Caprice, Impala, and Ford CVPI; and the Pirelli Pzero Nero on the Ford CVPI; and P6 tire on the Impala.

Tire evaluators purchased the tires from a retail store to ensure each tire was an actual production version. Goodyear, Firestone, Pirelli and Nitto categorized their test entries as "High Performance All Season," whereas Nokian labels its model as an "All Weather Plus" tire, and Cooper calls its tire a "Premium Luxury Touring" tire.

In the first set of braking tests of the Goodyear, Nitto, and Nokian tires on the Caprice, the Nitto tire performed best in wet and dry conditions. In the braking and turning test, the Nokian tire performed best.

In the test of the Cooper, Firestone, and Goodyear tires on the Charger, the Cooper tire performed best new in all three tests, but was too worn to be tested in the "worn" tests. The Goodyear and Firestone tires performed different in the dry vs. wet braking tests, with the Goodyear tire coming in first during the dry test and the Firestone coming in first in the wet, braking test. When braking during a turn for the worn tires, Goodyear came in first.

In the tests of the Goodyear and Firestone tests on the Tahoe, the new version of the Firestone tire performed better in three out of the four tests, but was too worn to be tested against the Goodyear tire in the "worn" tests.

For the Pirelli, Cooper, Goodyear, and Nokian tires tested on the Impala, the new version of the Cooper tire again had the best performance in four tests but was so worn it couldn't be tested against the other three in the "worn" tests.

On the Ford CVPI, where MSP tested the Goodyear, Cooper, Firestone, Nokian, and Nitto tires, again the new version of the Cooper tire performed best in two of the four tests but came in fourth in the braking-during-a-turn test, and third in the lateral acceleration test. The Cooper tire was too worn for testing in the "worn" tests, and the Nitto tire performed best in three of the four "worn" tire tests.

Replacement tire prices increased 4-13% in 2011 due to higher commodity costs used to manufacture tires, such as oil, rubber and steel, according to the 20th annual operating costs survey in Automotive Fleet magazine.

Read the full 352-page report at the Michigan State Police website. And watch a video of MSP troopers explaining the methodology of the tire evaluation.

Comments (3)

Displaying 1 - 3 of 3

Al @ 1/20/2012 11:49 AM

Question: Why were Michelin and/or BFGoodrich not included in this test?

Web Editor @ 1/30/2012 1:56 PM

@Al BFGoodrich is part of Firestone, so the Firehawk GT Pursuit would be used. Also, Michelin declined to identify a pursuit-rated tire for testing, Sgt. Matt Rogers of the driving unit tells POLICE Magazine.

Travis @ 2/3/2012 12:17 PM

Firestone is owned by Bridgestone. Michelin owns BFG.

Join the Discussion

POLICE Magazine does not tolerate comments that include profanity, personal attacks or antisocial behavior (such as "spamming" or "trolling"). This and other inappropriate content or material will be removed. We reserve the right to block any user who violates this, including removing all content posted by that user.

Other Recent Blog Posts

To Prevent School Shootings, Show Some Muscle
Deterrence is not just a matter of having armed personnel or even sworn officers in the...
Active Shooters, Gun Control, and Mental Health
If we are truly serious about reducing active shooter deaths, we must stop the political...

Get Your FREE Trial Issue and Win a Gift! Subscribe Today!
Yes! Please rush me my FREE TRIAL ISSUE of POLICE magazine and FREE Officer Survival Guide with tips and tactics to help me safely get out of 10 different situations.

Just fill in the form to the right and click the button to receive your FREE Trial Issue.

If POLICE does not satisfy you, just write "cancel" on the invoice and send it back. You'll pay nothing, and the FREE issue is yours to keep. If you enjoy POLICE, pay only $25 for a full one-year subscription (12 issues in all). Enjoy a savings of nearly 60% off the cover price!

Offer valid in US only. Outside U.S., click here.
Police Magazine